The precautions for maintaining the water tank of Huaquan generator mainly include the following aspects. I hope the following introduction can provide users with reference.
1、 Selection and Use of Cooling Fluid for Huaquan Generator
Type of coolant: Try to use coolant or soft water as the cooling water. If conditions limit the use of natural water sources such as river water, spring water, and well water, the water should be boiled and settled first, and then surface water should be taken for use to reduce the corrosion of impurities and minerals in the water tank.
Rust prevention treatment: If conditions permit, an appropriate amount of rust inhibitor can be added to the cooling water to enhance the rust prevention ability of the water tank.
2、 Daily inspection and maintenance of Huaquan generator water tank
Check the pipe joints: Regularly inspect the water tank pipe joints for leaks to ensure the sealing of the cooling system.
Maintain appropriate water level: Ensure that the water level in the tank is kept in the appropriate position, not too low or too high. For the upper chamber, the water level should not be lower than 8mm below the upper opening of the inlet pipe, and any lower level should be promptly replenished.
Huaquan generator water tank should be regularly filled and emptied: The water tank should be regularly filled with water to empty the air in the system and avoid adverse effects of air on the cooling system. At the same time, do not keep the radiator partially filled with water to avoid accelerating the corrosion process.
Cleaning the radiator: Regularly clean the exterior and interior of the radiator. External cleaning can be done by spraying low-pressure hot water (with appropriate cleaning agents added), paying attention to spraying from the front of the radiator towards the fan. Internal cleaning mainly involves removing scale from the water tank. Rust removal acid solution can be used for cleaning, but attention should be paid to the operating methods and safety precautions.
3、 Precautions for operating the water tank of Huaquan generator
Avoid high-temperature operation: During the operation of the generator set, the coolant in the radiator tank is usually very hot and under pressure. It is strictly prohibited to tidy up the radiator or remove the pipes before cooling. At the same time, do not operate the radiator or open the fan protective cover while the fan is rotating.
Correct method of adding water: When the diesel engine overheats and lacks water, the load should be removed first, and after the water temperature drops, it should be slowly added with a fine flow while running. If the diesel engine runs out of water during operation, water can only be added after the engine has stopped and the standby temperature has dropped to natural temperature. When draining water in cold weather, wait for the water temperature to drop to 40 ℃ before draining, open the water tank cover, and turn the crankshaft to drain the water from the water pump and other areas.
4、 Other maintenance matters for Huaquan generator
Check the leakage of the water pump: Observe the leakage of the drain hole under the water pump cover. Within 3 minutes of parking, the leakage should not exceed 6 drops. If it is too much, the water seal should be replaced.
Regular inspection of fan blades: For cooling fan systems using hydraulic couplings, the fan coupling should be cleaned regularly to ensure the normal operation of the fan.
Lubricate the water pump shaft bearings: After the diesel generator set has been working for a period of time, grease should be added to the water pump shaft bearings for lubrication.
In summary, the maintenance of the Huaquan generator water tank requires comprehensive consideration of the selection and use of coolant, daily inspection and maintenance of the water tank, operational precautions, and other related maintenance matters. Regular maintenance and upkeep can ensure the normal operation and extended service life of the generator.
More information on Huaquan generators:
http://www.wf-fadianji.com/
